Head-to-head test
Goal Zero Sherpa 100PD vs Jackery Explorer 500
Real-world runtimes, scenario verdicts, and ownership costs compared — which wins for your use case.
Written by Wenny ZhengUpdated
Portable Power Tester, Station Arena Test Desk
Goal Zero
Sherpa 100PD
793Power Score · Device Hub
$199.95 list · direct from Goal Zero
Jackery
Explorer 500
1,497Power Score · Device Hub
$359.00 list · direct from Jackery
Spec deltas
The Goal Zero Sherpa 100PD (95Wh) and Jackery Explorer 500 (518Wh) sit in different weight classes. The real question: do your power needs justify the larger unit, or would you be overpaying for capacity that sits unused? The Explorer 500 has a slight edge, but the margin is close enough that your use case should break the tie.
The Explorer 500 holds 423Wh more than the Sherpa 100PD — about 3 hours on a fridge against 1 — a real but modest edge that shows up mainly on longer outages. For camping, tailgating, or keeping devices charged, both have the headroom, so price, weight, and longevity lead the decision instead.
Pick the Explorer 500 if your primary use is cpap overnight. Go with the Sherpa 100PD if its specific strengths below line up better with your use. Most buyers stop at the sticker price and miss this: over a full lifespan the Explorer 500 works out to about $0.87/kWh against the Sherpa 100PD's $4.22, a gap that compounds in the Explorer 500's favor the more you cycle it. Keep scrolling for the full breakdown. The scenario verdicts below hold a few surprises.
Bench Notes
What each unit does well, where it falls short, and the trade-offs that matter.
Goal Zero Sherpa 100PD
At 100W, this unit is strictly for personal electronics (phones, laptops) and small CPAP machines. Do not expect to run kitchen appliances. At only 1.5 lbs, it is exceptionally portable. You can easily carry it one-handed to a campsite or tailgating party.
Strengths
- +Costs $159.1 less
- +Lighter by 11.8 lb
Trade-offs
- –Lacks smartphone app control for remote monitoring.
Jackery Explorer 500
At 500W, this unit is strictly for personal electronics (phones, laptops) and small CPAP machines. Do not expect to run kitchen appliances. At only 13.3 lbs, it is exceptionally portable. You can easily carry it one-handed to a campsite or tailgating party.
Strengths
- +Larger battery capacity
- +Higher AC output
- +Faster solar charging
Trade-offs
- –Substantially more expensive (+$159.1) than the Sherpa 100PD.
- –Significantly heavier (+11.8 lbs), making it harder to move.
- –Lacks smartphone app control for remote monitoring.
Will It Power Your Gear?
Scenario math and per-appliance runtimes, modeled from the spec record.
Scenario verdicts
We ran the math on six real-world scenarios. Here's which unit survives your actual life.
SCN-01 · 2 nights · needs 2,100Wh
Weekend Camping
Two nights off-grid with essential comfort
Neither unit
Neither unit covers this scenario's 2,100Wh: the Sherpa 100PD gets through about 4% of it and the Explorer 500 about 21%. This is well outside what either unit is for; the right answer here is a larger station, not a choice between these two.
Battery budget usedlower = more headroom
LOAD Phone Charger 15W×6h · LED Lights 40W×8h · Box Fan 75W×14h · CPAP Machine 40W×16h
SCN-02 · 8 hours · needs 1,645Wh
8-Hour Blackout
Keep the essentials running through a night without power
Neither unit
The Sherpa 100PD's inverter can't start the 150W peak this scenario needs, so capacity never gets a say. This is the wrong size of unit for the job rather than a close call.
Battery budget usedlower = more headroom
LOAD Fridge 150W×8h · Router + Modem 20W×8h · LED Lights (4 bulbs) 40W×6h · Phone Charger 15W×3h
SCN-03 · 8 hours · needs 320Wh
CPAP Overnight
Sleep therapy without interruption — the #1 medical use case
Explorer 500
The Sherpa 100PD runs out of juice. It only has 80Wh usable, but this scenario needs 320Wh. The Explorer 500 covers it and still has 8h of phone charging left over.
Battery budget usedlower = more headroom
LOAD CPAP Machine 40W×8h
SCN-04 · 8 hours · needs 910Wh
Remote Workday
Full work day off-grid without power anxiety
Neither unit
Neither unit covers this scenario's 910Wh: the Sherpa 100PD gets through about 9% of it and the Explorer 500 about 48%. This is well outside what either unit is for; the right answer here is a larger station, not a choice between these two.
Battery budget usedlower = more headroom
LOAD Laptop 60W×8h · External Monitor 30W×8h · Router + Modem 20W×8h · Phone Charger 15W×2h
SCN-05 · 4 hours · needs 670Wh
Tailgate Party
Game day power for the crew
Neither unit
The Sherpa 100PD's inverter can't start the 400W peak this scenario needs, so capacity never gets a say. This is the wrong size of unit for the job rather than a close call.
Battery budget usedlower = more headroom
LOAD Blender 400W×0.5h · LED TV (55") 80W×4h · Bluetooth Speaker 15W×4h · Phone Charger (×3) 45W×2h
SCN-06 · 24 hours · needs 4,685Wh
Van Life Daily
A full day of mobile living — the ultimate endurance test
Neither unit
The Sherpa 100PD's inverter can't start the 150W peak this scenario needs, so capacity never gets a say. This is the wrong size of unit for the job rather than a close call.
Battery budget usedlower = more headroom
LOAD Mini-Fridge 150W×24h · Laptop 60W×4h · Phone Charger 15W×3h · LED Lights 40W×5h · Fan 75W×8h
The Load Test
RUNTIME = (Wh × 0.85) ÷ LOAD
None of the six scenarios above exactly yours? Build it. Toggle what you'd plug in; both units are tested against the combined draw.
Essentials
Comfort & Convenience
High-Draw Appliances
Test duration
8h
Continuous draw
205W
Projected runtime
Only the Explorer 500 can start this 205W load.
$359 list · direct from Jackery
Modeled from the spec record — same math as the tables below. Methodology
Runtime by appliance
Real-world runtime estimates for common appliances, modeled at 85% inverter efficiency.¹
Essentials
The basics you need runningscale 0–29.4hComfort & Convenience
Makes off-grid life actually enjoyablescale 0–5.9hHigh-Draw Appliances
These reveal the real limits¹ Runtime = (capacity × 0.85) ÷ appliance watts. Within each group, all bars share one time scale (the group's longest runtime), so lengths are comparable across appliances; identical runtimes collapse into a single blue/orange bar. Actual runtime varies with battery age, temperature, and simultaneous loads — see methodology.
Conclusion
July 10, 2026
Verdict: the Explorer 500, on Power Score margin
These two units are closely matched on individual specs, but our Power Score analysis gives the Explorer 500 the edge with a composite score of 1,497 vs 793.
Overall score margin: 793 vs 1,497 (−88.8%)
List prices as of July 10, 2026. The links below open Goal Zero's and Jackery's current prices.
$359.00 list · direct from Jackery
or check the Sherpa 100PD price$199.95 list
Written by Wenny Zheng, Portable Power Tester · Station Arena Test Desk · Updated July 10, 2026
Measured Data
Benchmark scores and the full spec record, side by side.
Benchmark scores
Not rated for both units (minimum threshold unmet): Apartment Balcony, Camping.
Full specifications
ᵈ Derived: price ÷ rated capacity. See the data behind our comparisons →
Comparison ToolAdd more power stations, side by sideOpen Tool →How these numbers are produced
Numeric verification
Every figure on this page traces to our spec database or arithmetic on it — no estimated numbers.
Owner claims
Statements about owner experience are cited to published reviews.
Runtime model
Runtime = (rated capacity × 0.85 inverter efficiency) ÷ device wattage. Solar recharge estimates assume panels deliver 70% of rated output. Cold weather, battery age, and stacked loads reduce real-world results.
Power Score
Computed from 14 published spec dimensions, weighted per use-case bench. Higher is better; a unit must meet a bench's minimum threshold to be rated.
See the full weight table and data sourcing on our methodology page →Class ranking (the star rating)
Each unit's star score is a category ranking, not customer reviews — no buyer opinions feed it. We score every station on size-independent quality (value, output, portability, endurance, ports, warranty, and more), then percentile-rank it against the other units in its capacity class, so a class-leading compact unit and a class-leading whole-home unit can both earn 5★. Here, Sherpa 100PD rates 3.4/5 (5th percentile of 22 Personal-class units), and Explorer 500 rates 3.3/5 (1st percentile of 19 Compact-class units).
How the class ranking is computed →Test Notes & Caveats
Hidden gotchas and advantages we spotted that you won't find on the product page.
Explorer 500: Solar Recharge Takes 7.4h
At 100W max solar input (realistically ~70W in good conditions), recharging the full 518Wh takes roughly 7.4 hours of direct sun. Not practical for daily off-grid use. You'll need a wall outlet or generator for regular recharging.
Warranty Value Comparison
The Sherpa 100PD gives you 10 years of warranty per $1,000 spent, vs the Explorer 500's 5.6 years. That's 1.8× more coverage per dollar. An underrated factor if you're keeping this unit for years.
Sherpa 100PD: Noise Level Not Disclosed
The Explorer 500 publishes its noise level (37dB); the Sherpa 100PD doesn't publish one. That isn't evidence the Sherpa 100PD is louder — it means there's no figure to hold it to, and no way to compare the two on this without hearing them. If you're buying for a bedroom, a CPAP, or an apartment, treat the Explorer 500's 37dB as the only measured number on the table and look for hands-on reports of the Sherpa 100PD before deciding.
Full record above — the Test Desk pick is the Explorer 500.
Check Explorer 500 price →or check the Sherpa 100PD priceOwnership Analysis
What happens after you buy — true cost of ownership, brand trust, and growth potential.
Lifetime value
Service lifeyears at one full cycle per day
Lifetime energy delivered
Cost per delivered kWh
│ warranty ends · Reaching the cycle rating means ~80% capacity remains — degraded, not dead.
Analyst note
The Sherpa 100PD is cheaper to buy, but the Explorer 500 is cheaper to own. At $0.87/kWh over its lifetime vs $4.22/kWh, the Explorer 500's higher cycle life and capacity make each dollar go further over the years.
Delivers each lifetime kWh for $3.35 less — check the Explorer 500 price →
Brand trust
Goal Zero
Ecosystem
Focused — 5-6 active portable power station models across Yeti and Yeti Pro series, plus Alta coolers, Nomad/Ranger solar panels, and vehicle integration kits
Support
US-based company (Salt Lake City, owned by NRG Energy). Historically considered premium support, but 2025-2026 reports describe long wait times, unresponsive email communication, and tickets going unaddressed for weeks. The "premium support justifies premium pricing" argument is weakening.
Community
Small but loyal — strong following in overlanding and preparedness communities. Official community forums were recently shuttered, frustrating long-time users.
App experience
Rated 4.4/5 iOS (~1,200 ratings) but recent reviews skew negative — recurring connectivity issues, crashes, and stability problems.
Unique strength
Pioneer of the portable power market — strongest brand heritage. US-based company with ruggedized, weather-resistant designs (IPX4). Integrated "Yeti-Ready" ecosystem with coolers, lights, and vehicle kits.
Worth knowing
Widely acknowledged as the most expensive brand (lowest Wh per dollar). Support quality has declined from its "premium" standard. Perceived as competitively stagnant vs. faster-innovating Chinese competitors. Reliability reports on newer models are concerning.
Jackery
Ecosystem
12-15+ models across Explorer (portable) and HomePower (home backup) series, plus SolarSaga panel ecosystem and innovative form factors
Support
US-based support but widely criticized. Reddit reports describe slow/dismissive responses, scripted AI agents, strict receipt requirements for warranty claims, and refurbished replacements for clearly defective units. Strongly recommended: buy from Costco or Amazon for return protection.
Community
Smallest community of the major brands — Reddit r/Jackery has ~2,000 members. YouTube presence is solid due to brand recognition.
App experience
Rated 2.3-3.3/5 iOS and Android — the weakest app experience of the major brands. Multiple confusing apps (Jackery app vs Jackery Home) and mandatory login even offline.
Unique strength
Highest brand recognition and widest retail distribution (Costco, Home Depot, Best Buy, Amazon). The "Toyota" of power stations — dependable, proven, wide availability. Innovative form factors like the Solar Gazebo and Solar Mars Bot.
Worth knowing
A couple of older models still ship NMC chemistry with a shorter rated lifespan, so check the cycle rating on the specific unit — though most of the current line has moved to LFP. Generally perceived as overpriced for the specs offered compared to newer competitors. App experience is significantly behind rivals.
Analyst note
Goal Zero positions itself as a premium brand with stronger support infrastructure, while Jackery competes on value. The question is whether the Goal Zero ecosystem and support premium is worth it for your use case.
Growth path
Sherpa 100PD
FIXED CAPACITYFixed at 95Wh, with no expansion — so size it for your needs up front rather than planning to add capacity later.
Accepts up to 20W of solar. Limited to a single portable panel.
Limited ports. You'll likely need a power strip or splitter.
Explorer 500
FIXED CAPACITYFixed at 518Wh, with no expansion — so size it for your needs up front rather than planning to add capacity later.
Accepts up to 100W of solar. Limited to a single portable panel.
Limited ports. You'll likely need a power strip or splitter.
Realistic full solar rechargeat 70% of rated panel output — see methodology
Analyst note
Neither expands, and that's no knock on either — each is a complete unit at a fixed size. Buy the capacity that covers your needs now (the Explorer 500 gives you the larger ceiling); you can't add to either later.
The Bottom Line
The full picture comes down to this. The Explorer 500 edges ahead on our overall analysis, but the margin is narrow enough that your specific use case should drive the decision. Review the scenario verdicts above — if the Sherpa 100PD wins in the scenarios that match your life, it's the right choice regardless of aggregate scores.
If neither the Sherpa 100PD nor the Explorer 500 feels like the right fit, your power needs probably sit outside what these two target. If you're planning whole-home backup or running power-hungry appliances (electric heaters, window AC), you'll want a larger system in the 3,000–5,000Wh range with expansion battery support. Prices on portable power stations fluctuate frequently. Both Goal Zero and Jackery discount regularly, so check the current price before committing. Prime Day and Black Friday pricing typically drops 20-30%.
Frequently Asked Questions
Answers drawn from the spec record and cited owner research.
Is the Explorer 500 worth $159.1 more than the Sherpa 100PD?
The short answer: yes, if you'll actually use the extra capability. The Explorer 500 costs $159.1 more, but that premium buys you 423.3Wh more battery capacity (that's 2 extra hours of running a mini-fridge); 400W higher AC output (opening the door to more demanding appliances); a longer-lasting battery rated for 800 cycles — that's 2 years at daily use; 80W faster solar charging for quicker off-grid recovery. On a cost-per-watt-hour basis, you're paying $0.69/Wh vs $2.11/Wh. Factor in cycle life and the math flips: the Explorer 500 costs $0.87/kWh over its lifetime vs $4.22/kWh. The "expensive" unit is actually cheaper to own. For regular use, we'd pay the premium.
Can I actually carry the Explorer 500, or is the Sherpa 100PD the only portable option?
The Sherpa 100PD at 1.5 lbs is genuinely grab-and-go. Toss it in a backpack, carry it one-handed to a picnic, take it on a boat. The Explorer 500 at 13.3 lbs is a different story. It's like carrying a large suitcase full of books. If you're setting up and breaking down camp frequently, this weight difference will exhaust you by day two.
Is Goal Zero or Jackery more reliable for long-term ownership?
Both brands have strengths and trade-offs. Goal Zero: 5 years on LFP models, 2 years on older NMC models. Battery must be charged within 7 days of purchase and every 6 months to maintain warranty (strict). Product reliability concerns have increased — repeat "Battery Fault" errors reported even on newer Yeti Pro 4000. Jackery: 2-5 years depending on model (premium models like 5000 Plus get 5 years, budget models get 2 years). Registration required for extension. Claims process can be frustrating. One piece of advice from the power station community: regardless of brand, buy from Costco or Amazon. Their return policies provide a safety net that manufacturer warranties alone can't match, especially for a product you'll rely on in emergencies. Both brands use LFP (lithium iron phosphate) batteries in their current lineup, the most proven chemistry for longevity and safety.
Bottom line: should I buy the Sherpa 100PD or the Explorer 500?
We'd pay the premium for the Explorer 500. Yes, it costs more. The capability jump is real: you're stepping into a tier that handles appliances the base model can't start. The Sherpa 100PD is still solid if budget is the priority, but the Explorer 500 will leave you less likely to wish you'd "gone bigger" six months from now. That regret costs more than the price difference.
Where to buy
Goal Zero Sherpa 100PD
$199.95
$199.95 list · direct from Goal Zero
Jackery Explorer 500Pick
$359.00
$359.00 list · direct from Jackery
Prices may vary by retailer and are subject to change.